A total of eight types of organic wastewater were used in the study. Gas washing water (A), sulfur water (B), carbonized water (C) and slag discharge water (D) were the coal gasification wastewater produced by the entrained bed process; Yima wastewater (F) was coal gasification wastewater produced by the crushed coal fixed bed process (Lurgi furnace); coking wastewater (E) was produced by the ...
Abstract Dispersants, serving as an essential raw material in the formulation of coal water slurry, offer an economical and convenient solution for enhancing slurry concentration, thus stimulating significant interest in the development of novel and efficient dispersants.
Coalwater slurry fuel is a fuel that is domestic, in large supply, can be handled like a liquid, burns like coal, costs like coal, and has the potential as a near term alternative to No. 6 fuel oil. Unlike the coal gasification and liquefication processes, the capital investment required is modest.
Coal slurry pipeline transportation refers to the process of using highpressure pumps to continuously transport coal slurry through closed pipes to endusers ( Lahiri and Ghanta, 2008 ).
Therefore, there are many methods studied for saving energy and increasing efficiency of hydrogen production [7], [8], [9]. CWS (coal water slurry) electrolysis not only could increase efficiency of hydrogen production (Faraday current efficiency closed to 100%) from water electrolysis [10], [11], but also could achieve purity of coal, such as ...
Municipal sludge (MS) is used to prepare coal water slurry (CWS). This practice is beneficial for resource utilization and reduces treatment costs and environmental pollution. In this study, alkalimodified municipal sludge (AMS) was prepared with Ca(OH)2 as modifier and mixed with coal to produce AMSCWS. The effect and mechanism of MS and AMS on slurry ability, stability, and combustion ...
Coal water slurry (CWS), a highlyloaded suspension of coal in water, is regarded as one of the most important alternatives for fuel oil. Generally, additives are required for the preparation of CWS, of which polycarboxylate (PC) is the most promising and applicable one. ... Coal plays a vital role in maintaining the economic growth process ...
The coalwater slurry can be provided at a high coal content so that the slurry can be burned directly without need for dewatering at its destination.}, doi = {}, url = ... A process for preparing a carbonaceous slurry with a Brookfield viscosity of less than 5,000 centipoise when it is measured at a solids content of 70 volume percent, ambient ...
Dispersion mechanism of coal water slurry prepared by mixing various highconcentration organic waste liquids Shuangni Wang a, Jianzhong Liu a, Sarma V. Pisupati b, Dedi Li a, Zhihua Wang a, Jun Cheng a Add to Mendeley https://// Get rights and content Abstract
It was found that activation energy of conversion is E = 103 kJ/mol and the preexponential factor is A0 = × 10 s 1. It was revealed that coal gasification in SCW without oxidants is the weakly endothermic process. The addition of CO 2 into SCW decreases the conversion rate and increases the CO yield.
Methanol is an important feedstock of chemical engineering and energy source, and it is mainly produced by coal route in China. The coaltomethanol suffers from serious CO 2 emissions and carbon resource waste since water gas shift is involved in this process to increase hydrogen content of syngas for meeting methanol novel coaltomethanol process integrated with cokeoven gas ...
The purpose of this research is to determine the effect of the series system on the SCWG of watercoal slurry. This paper has established an innovative series SCWG system and modeled the entire flowsheet. ... Thermodynamic study on the integrated supercritical water gasification with reforming process for hydrogen production: effects of ...
Coalwater slurry is a new, efficient and clean coalbased fuel. It is a mixture of 6570% coal with different particle size distribution, 2934% water and about 1% chemical additive. Many countries have researched and developed it as coalbased fuel technologies based on longterm energy strategy considerations.
The main production process of BDO is the Reppe method. In the purification process ... on the gasification process of coal water slurry, the SEMEDX (Tescan VEGA3 SBHBRUKER XFlash 6|30, Germany ...
Illustration of concentrated suspensions showing that at a given solid's content the volume of sediment depends on particle aggregation. Source: After Laskowski and Parfitt, 1989 with permission of Taylor Francis.
As a part of clean coal technology, the coal water slurry has a popular application in the conventional and new thermal power stations. The hydrotransport is nowadays a preferred method, due to its low specific energy consumption and nonpolluting nature. The lignites and high ash coals, available in abundance, show poor slurryability, thereby making the process unsustainable.
Simplified block diagram of gasification process for syngas production. Coal slurry is first prepared by crushing the coal to a size of mm particle diameter along with water addition. The coal slurry is the pumped to the gasifier where the reactions take place in the controlled amount of oxygen.
(b) In the industrial application process, the active component of the syngas produced from the gasification of the coal mixed wastewater slurry can reach % and has a higher H2 content than ...
The coal gasification process produces a large amount of wastewater which is seriously polluted and difficult to biochemically treat. The regasification of coal water slurry produced from gasification wastewater meets the requirements of clean and efficient use of energy and the concept of circular economy.
The prepared coalwater slurry consisted of 23% to 50% Lochiel coal and 40% Bowman's coal. The authors found that the solid concentration a ff ected the nature of the slurry, with 23% Newtonian
To improve the efficiency of the gasification or combustion process of coal water slurry (CWS), it is significant to optimize the rheological properties and increase the solid concentration of CWS. Particularly, preparing CWS from low quality coal remains a peculiarly intriguing subject due to the large reserve and low price of low quality ...
Fig. 1 shows the production process of BDO tar [7]. ... Some chemical wastes mix into coalwaterslurry (CWS) in a proportion known as wastecoalwaterslurry (WCWS), which can control waste releases and recycle valuable resources. With the development of the gasification technology of CWS, the adaptability of raw materials is continually ...
DOI: / Corpus ID: ; Study on coal water slurries prepared from coal chemical wastewater and their industrial application article{Li2020StudyOC, title={Study on coal water slurries prepared from coal chemical wastewater and their industrial application}, author={Dedi Li and Jianzhong Liu and Shuangni Wang and Jun Cheng}, journal={Applied Energy}, year ...
This paper reports a novel process that consists of two steps: the oxidation of the coal slurry by ferric ions (III) in a hydrothermal reactor at a temperature of 120160 °C and the electrooxidation of ferric ions (II) in the electrochemical cell to produce hydrogen.
Coal water slurry (CWS) is an important cleancoalbased liquid fuel with the characteristics of highefficiency and lowpollution. This paper aims to implement the principles of clean production and prepare CWS by coblending coal particles and polyethylene terephthalate (PET) microplastics.
Municipal sewage sludge always includes considerable amount of water, noxious substances, and varying chemical compositions; therefore, sludge utilization is imposed. Coalsludge slurry (CSS), which is made by blending sewage sludge with coal, water, and additives, is being identified as a new and effective sludge utilization technology. The main objectives of the present investigation are ...
The development of ecologically clean technology for coal use in terms of the coalwater slurry usage. I. A. Korotkiy E. N. Neverov V. Murko O. Chernikova. Environmental Science. 2021. The baseline conditions of technology for producing and burning coalwater slurries in Russia and foreign countries is exposed.
One of the lots was of ultraclean coalwater slurry fuel (UCCSF) for which a twostage caustic and acid leaching procedure was developed to chemically clean the coal. As a part of the contract, AMAX R and D more » developed a conceptual design and preliminary cost estimate for a commercialscale process for UCCSF manufacture.
In 2021, Chen [34] investigated the influence of coal rank on coalassisted water electrolysis for hydrogen production, utilizing a constant potential of approximately V, which remains below V. These studies laid the foundation for the application of CWS electrolysis and demonstrated the energysaving potential through anodic CWS ...
© DZCrusher - كل الحقوق محفوظة
